Stainless steel rolling shutter door needs our careful care! At present, this kind of stainless steel rolling shutter door plays an important role in our production and life. It is made of high-quality stainless steel and has advantages in various aspects in practical application. Here are the maintenance methods of stainless steel rolling shutter door.

一方面，我们在平时不锈钢卷帘门的过程中，应定期检查不锈钢卷帘门的固定轨道支架结构，如：支架出现松动，应及时拧紧螺栓。将不锈钢卷帘门关闭，检查轨道是否存在凹陷或者弯曲的现象，如发现有变形的现象，需要用橡皮手锤敲打变形地方加以校正，如轨道的损坏程度严重，必须立即更换新的轨道结构。

On the one hand, in the process of stainless steel rolling shutter door, we should regularly check the fixed track bracket structure of stainless steel rolling shutter door, such as: if the bracket is loose, the bolt should be tightened in time. Close the stainless steel rolling shutter door and check whether the track is sunken or bent. If the deformation is found, it is necessary to knock the deformed place with a rubber hammer to correct it. If the track is seriously damaged, a new track structure must be replaced immediately.

同时还要检查所有松动部位并及时拧紧。在上掀门上，检查安装弹簧平板，确保螺钉已旋紧，将变松螺钉拧紧。检查所有的铰链，将所有变松螺钉拧紧，将受损铰链更换成新件。

At the same time, check all loose parts and tighten them in time. On the upper lift door, check and install the spring plate, make sure the screw is tightened, and tighten the loose screw. Check all hinges, tighten all loose screws and replace damaged hinges with new ones.

济南卷帘门

Jinan roller shutter door

另一方面，我们在平时不锈钢卷帘门的过程中，对不锈钢卷帘门轨道的清洁与润滑操作作，可利用高浓度的家用洗涤剂来清洗其轨道，去除表面的污垢和硬化油脂。此时需注意将转轴的位置，一定要彻底清洗干净，然后再将不锈钢卷帘门的轨道及转轴位置擦干净。

On the other hand, in the process of stainless steel rolling shutter door, we can use high concentration household detergent to clean and lubricate the track of stainless steel rolling shutter door to remove the dirt and hardening grease on the surface. At this time, it is necessary to pay attention to the position of the rotating shaft, and then clean the track and shaft position of the stainless steel rolling shutter door.

对于润滑，可利用石墨粉撒在轨道上，用家用润滑油或者是硅树脂喷涂在转轴上或是在轨道以及转轴上，喷洒不锈钢卷帘门专用的润滑油喷剂，从而来获得良好的润滑程度。如果不锈钢卷帘门上安装有滑轮结构的话，我们需要使用与转轴上使用相同的润滑剂对其加以润滑，保证不锈钢卷帘门各部件的良好润滑条件，使其可靠运行。

For lubrication, graphite powder can be used to sprinkle on the track, household lubricating oil or silicone resin is used to spray on the rotating shaft or on the track and rotating shaft, and the special lubricating oil spray for stainless steel rolling shutter door can be sprayed, so as to obtain a good degree of lubrication. If the pulley structure is installed on the stainless steel rolling shutter door, we need to use the same lubricant as the rotary shaft to lubricate it, so as to ensure the good lubrication conditions of all parts of the stainless steel rolling shutter door and make it operate reliably.